在線咨詢
官方二維碼
當前位置：
2020.04.02
燃?xì)獍l(fā)電機組機房設置、配套設備有哪些要注意的？
燃?xì)獍l(fā)電機組對運行環境和配套設備要求較高。如果處理不當，很容易造成災難。在使用燃?xì)獍l(fā)電機組時除了以下規定外，還要根據具體情況，制定操作規程，并嚴格遵守。讓我們來看看使用燃?xì)獍l(fā)電機組時應該注意什么!
Gas generator sets have high requirements for operation environment and supporting equipment. If not handled properly, it is easy to cause disaster. In addition to the following regulations, the operating procedures shall be formulated and strictly followed according to the specific conditions when using gas generator set. Let's see what we should pay attention to when we use gas generator set!
一、機房設置要合理
1、 Reasonable setting of machine room
1.機房一般采用開式或半開式，地面應平整，便于清潔。
1. The machine room is generally open or semi open, and the ground shall be flat and easy to clean.
2.封閉式機房應按防爆要求設計。它應該是一座所有門窗都開著的單層建筑。
2. The enclosed machine room shall be designed according to the explosion-proof requirements. It should be a single story building with all the doors and windows open.
3.機房和操作室要分開。觀察窗為雙層玻璃，用鋼絲網保護。
3. the machine room and operation room shall be separated. The observation window is double-layer glass, protected by steel wire mesh.
4.機房應設有防雷裝置。
4. The machine room shall be equipped with lightning protection device.
5.燃?xì)獍l(fā)電機組運行現場不得有明火，不得設置“禁止燃放煙花爆竹”等警示標志。
5. There shall be no open fire and warning signs such as "no fireworks and firecrackers".
6.足夠的消防設備。
6. Sufficient fire fighting equipment.
7.將發動機排氣系統的廢氣與可燃?xì)怏w混合，從發動機設計安裝到室外排氣管系統。
7. Mix exhaust gas of engine exhaust system with combustible gas, and install it from engine design to outdoor exhaust pipe system.
二、燃?xì)獍l(fā)電機組及配套設備應符合標準要求
2、 Gas generator unit and supporting equipment shall meet the standard requirements
1.燃?xì)獍l(fā)電機組機房電氣設施應防爆，檢修時應切斷電源。
1. The electrical facilities in the gas generator room shall be explosion-proof, and the power supply shall be cut off during maintenance.
2.設置應急閥，在車間發生緊急情況時切斷氣源。閥門應該靠近手術室。
2. Set emergency valve to cut off the air source in case of emergency in the workshop. The valve should be close to the operating room.
3.氣體發生器室應安裝氣體濃度報警器。
3. A gas concentration alarm shall be installed in the gas generator room.
三、燃?xì)夤艿缿?yīng)當達到規定的標準，并及時修復
3、 The gas pipeline shall meet the specified standards and be repaired in time
1.燃?xì)夤艿啦捎煤癖阡摴?，接頭密封良好。
1. The gas pipeline adopts thick wall steel pipe, and the joint is well sealed.
2.定期檢查閥門，及時維修或更換閥門。
2. Check the valve regularly and repair or replace the valve in time.
3.燃?xì)夤艿郎系哪z管應定期更換，禁止老化膠管。
3. The rubber hose on the gas pipeline shall be replaced regularly, and aging rubber hose is prohibited.
4.燃?xì)獍l(fā)電機組及輸氣管道維修期間，應切斷氣源，排盡氣體。在查明事故原因并采取相應措施之前，不得將燃?xì)饣謴?fù)到燃?xì)庠O(shè)施。維修時應采取防爆措施或使用防爆工具。嚴禁用鐵器敲打。
4. During the maintenance of gas generator unit and gas transmission pipeline, cut off the air source and exhaust the gas. Before finding out the cause of the accident and taking corresponding measures, the gas shall not be restored to the gas facilities. Explosion proof measures shall be taken or explosion-proof tools shall be used during maintenance. It is forbidden to knock with iron.
燃?xì)獍l(fā)電機組在使用過程中需要更加注意嚴格按照規章制度操作。在燃?xì)獍l(fā)電機組的選擇上要選擇合格的廠家，這樣才能保證產品的質量。
In the process of using the gas generator set, more attention should be paid to operating in strict accordance with the rules and regulations. In the selection of gas-fired generator units, qualified manufacturers should be selected, so as to ensure the quality of products.