The failure of coking power generation unit is mainly caused by the unit being in static state for a long time. Various materials of the unit will undergo complex chemical and physical changes with oil, cooling water, diesel and air, mainly in two aspects. The small series of green rings are summarized as follows: the filter is used for the filtering function of diesel oil, engine oil or water to prevent impurities from entering the body. In the process of unit operation, the filter plays an important role, but at the same time, the oil pollution or impurities will be placed on the screen wall, making the filtering capacity, too much deposit, and the oil will not be opened, As a result, the diesel engine with the carrier will not be able to supply shock (as a person's oxygen) for the oil.

　　因此，在使用正常發電機組時，焦化發電機組廠家小編建議:

　　Therefore, when using the normal generator set, it is suggested that the manufacturer of coking generator set make up the following suggestions:

　　一是普通機組每500小時更換一次濾清器;

　　One is to replace the filter every 500 hours for ordinary unit;

　　第二，備用單位應該每?jī)赡旮鼡Q三個過濾器。

　　Second, the standby unit should replace three filters every two years.

　　水泵、水箱和水傳輸管道還沒有打掃很長一段時間,所以水循環不光滑,冷卻效果降低,水管接頭是否良好,是否水箱、水泄漏,等等,如果冷卻系統故障,后果是:,冷卻效果不好,單位的水溫過高和關閉;

　　The water pump, water tank and water transmission pipeline have not been cleaned for a long time, so the water circulation is not smooth, the cooling effect is reduced, whether the water pipe joint is good, whether the water tank and water leak, etc. if the cooling system fails, the consequences are: first, the cooling effect is not good, the unit water temperature is too high and closed;

　　其次，水箱漏水，使水箱內的水位下降，機組將無法正常工作(為了防止冬季使用發電機，水管結冰，建議更好安裝熱水器在冷卻系統中。由于備用電源無法避免大部分時間處于待機狀態，所以為了防止上述現象，加強日常維護將是更經濟有效的方法。

　　Secondly, the water tank leaks, so that the water level in the water tank drops, and the unit will not work normally (in order to prevent the generator from being used in winter and the water pipe from freezing, it is recommended to install the water heater in the cooling system). Because the standby power supply can not avoid being in standby state most of the time, in order to prevent the above phenomenon, strengthening daily maintenance will be the most economical and effective method.

　　以上是焦化發電機組廠家為大家介紹的相關內容，想要了解更多內容，歡迎訪問網站：http://www.kan138.cn

　　The above is the relevant content introduced by the coking generator set manufacturer. For more information, please visit the website: http://www.kan138.cn